Welcome to Journal of Beijing Institute of Technology
Advance Search
Volume 27Issue 1
.
Turn off MathJax
Article Contents
Article Navigation> JOURNAL OF BEIJING INSTITUTE OF TECHNOLOGY> 2018> 27(1): 83-91
Yonglin Jiang, Bingguo Liu, Jinhui Peng, Libo Zhang. Dielectric Properties and Microwave Heating of Molybdenite Concentrate at 2.45 GHz Frequency[J]. JOURNAL OF BEIJING INSTITUTE OF TECHNOLOGY, 2018, 27(1): 83-91. doi: 10.15918/j.jbit1004-0579.201827.0111
Citation: Yonglin Jiang, Bingguo Liu, Jinhui Peng, Libo Zhang. Dielectric Properties and Microwave Heating of Molybdenite Concentrate at 2.45 GHz Frequency[J].JOURNAL OF BEIJING INSTITUTE OF TECHNOLOGY, 2018, 27(1): 83-91.doi:10.15918/j.jbit1004-0579.201827.0111
shu

Dielectric Properties and Microwave Heating of Molybdenite Concentrate at 2.45 GHz Frequency

doi:10.15918/j.jbit1004-0579.201827.0111

  • National Local Joint Engineering Laboratory of Engineering Applications of Microwave Energy and Equipment Technology, Kunming 650093, China;Key Laboratory of Unconventional Metallurgy, Ministry of Education, Kunming University of Science and Technology, Kunming 650093, China;Faculty of Metallurgical and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, China

  • Received Date:2017-06-30
    Abstract
  • Dielectric properties were measured using cavity perturbation method.The temperature rising behaviors of molybdenite concentrate were investigated in the field of microwave.This process was conducted to show the microwave absorption properties of molybdenite concentrate and the feasibility of microwave roasting molybdenite concentrate to prepare high purity M OO 3.The dielectric constant,dielectric loss,and loss tangent increase from 3.51 to 5.04,0.22 to 0.51 and 0.065 to 0.102 respectively.They are proportional to the apparent density of molybdenite concentrate in the range of 0.9-1.4 g/cm 3.The results show that the molybdenite concentrate has good microwave absorption capacity in the conventional density range.The temperature rising curves show that the apparent heating rate of the molybdenite concentrate increases with the increase in microwave power and decreases with the increase in the sample mass and thickness.The temperature of concentrate sample of 100g reaches approximately 800℃ after 5 min of microwave treatment at 0.5 kW of power. Our findings show that it is feasible to prepare high-purity M OO 3from molybdenite concentrate by microwave roasting.
    • FullText(HTML)
  • loading
    • References (29)
  • [1]
    Sharma R K, Reddy G B. Effect of substrate on the growth of α-M OO 3nanostructures via plasma assisted sublimation process[J]. Physical B, 2015,456: 197-205.
    [2]
    Ette P M, Gurunathan P, Ramesha K. Self-assembled lamellar α-molybdenum trioxide as high performing anode material for lithium-ion batteries[J]. Journal of Power Sources, 2015, 278:630638.
    [3]
    Fernandes C I, Capelli S C, Vaz P D, et al. Highly selective and recyclable MoO 3nanoparticles in epoxidation catalysis[J]. Applied Catalysis A:General, 2015, 504:345-456.
    [4]
    Kumar V V, Gayathri K, Anthony S P. Synthesis of α-MoO 3nanoplates using organic aliphatic acids and investigation of sunlight enhanced photodegradation of organic dyes[J]. Materials Research Bulletin, 2016, 76:147-154.
    [5]
    Alaie M M, Jahangiri M, Rashidi A M, et al. Selective hydrogen sulfide (H 2S) sensors based on molybdenum trioxide (MoO 3) nanoparticle decorated reduced graphene oxide[J]. Materials Science in Semiconductor Processing, 2015, 38:93-100.
    [6]
    Deki S, BélékéA B, Kotani Y, et al. Liquid phase deposition synthesis of hexagonal molybdenum trioxide thin films[J]. Journal of Solid State Chemistry, 2009, 182(9):2362-2367.
    [7]
    Julien C, Nazri G A. Transport properties of lithium-intercalated MoO 3[J]. Solid State Ionics, 1994, 68(1-2):111-116.
    [8]
    Zhang Qixiu, Zhao Qinsheng. Metallurgy of tungsten and molybdenum[M]. Beijing:Metallurgical Industry Press, 2005. (in Chinese)
    [9]
    Ye Yinping, Chen Jianmin, Zhou Huidi. An investigation of friction and wear performances of bonded molybdenum disulfide solid film lubricants in fretting conditions[J]. Wear Volume, 2009, 266(78):859-964.
    [10]
    Ellefson C A, Flores O M, Ha S. Synthesis and applications of molybdenum (IV) oxide[J]. Journal of Materials Science, 2012, 47:2058-2059.
    [11]
    Xiang Tiegen. Molybdenum metallurgy[M]. Changsha:Central South University Press, 2002. (in Chinese)
    [12]
    Bergman T L, Lavine A S, Incropera F P, et al. Fundamentals of heat and mass transfer[M]. Hoboken:John Wiley, 2011.
    [13]
    Hassan M N, Mahmoud M M, Fattah A A, et al. Microwave-assisted preparation of nanohydroxyapatite for bone substitutes[J]. Ceramics International, 2016, 42:3725-3744.
    [14]
    Tuichai W, Srepusharawoot P, Swatsitang E, et al. Giant dielectric permittivity and electronic structure in (Al + Sb)co-doped TiO 2ceramics[J]. Microelectronic Engineering, 2015, 146:32-37.
    [15]
    Maurya D, Sun Fuchang, Alpay S P, et al. A new method for achieving enhanced dielectric response over a wide temperature range[J]. Scientific Reports, 2015, 15144.
    [16]
    Tang Rujun, Jiang Chen, Qian Wenhu, et al. Dielectric relaxation, resonance and scaling behaviors in Sr 3Co 2Fe 24O 41hexaferrite[J]. Scientific Reports, 2015,13645.
    [17]
    Boreddy S R, Subbiah J. Temperature and moisture dependent dielectric properties of egg white powder[J]. Journal of Food Engineering, 2016, 168:60-67.
    [18]
    Salema A A, Yeow Y K, Ishaque K, et al. Dielectric properties and microwave heating of oil palm biomass and biochar[J]. Industrial Crops and Products, 2013, 50:366-374.
    [19]
    Sheen J. Measurements of microwave dielectric properties by an amended cavity perturbation technique[J]. Measurement, 2009, 42:57-61.
    [20]
    Sheen J. Amendment of cavity perturbation technique for loss tangentmeasurement at microwave frequencies[J]. Journal of Applied Physics, 2007, 014102.
    [21]
    Xu Feng, Dong Bo, Hu Xiaofang, et al. Discussion on magnetic-induced polarization Ampere's force by in situ observing the special particle growth of alumina during microwave sintering[J]. Ceramics International, 2016, 42(7):8296-8302.
    [22]
    Tripathi M, Sahu J N, Ganesan P, et al. Effect of temperature on dielectric properties and penetration depth of oil palm shell (OPS) and OPS char synthesized by microwave pyrolysis of OPS[J]. Fuel, 2015, 153:257-266.
    [23]
    Peng Jinhui, Yang Xianwan. New applications of microwave power[M]. Kunming:Yunnan Science and Technology Press,1997. (in Chinese)
    [24]
    Zhang Libo, Ma Aiyuan, Liu Chenhui, Dielectric properties and temperature increase characteristics of zinc oxide dust form fuming furnace[J]. Transactions of Nonferrous Metals Society of China, 2014, 24(12):4004-4011.
    [25]
    Pozar D M. Microwave engineering[M]. Hoboken:John Wiley, 2012.
    [26]
    Han Rui, Li Wei, Pan Weiwei, et al. 1D magnetic materials of Fe 3O 4and Fe with high performance of microwave absorption fabricated by electrospinning method[J]. Scientific reports, 2014:7493.
    [27]
    Gao Enyu, Bilén S G, Yang Shuxing. Analysis and numerical modeling of a 20 W microwave electrothermal thruster[J]. Journal of Beijing Institute of Technology, 2010, 19(3):324-330.
    [28]
    Chen Xiaoyu. Researches on preparing molybdenum trioxide by the oxidation boasting by microwave[D]. Kunming:Kunming University of Science and Technology,2015, 36-37. (in Chinese)
    [29]
    Siciliano T, Tepore A, Filippo E. Characteristics of molybdenum trioxide nanobelts prepared by thermal evaporation technique[J]. Materials Chemistry and Physics, 2009, 114:687-691.
    • Relative Articles
  • Supplements (0)
  • Cited By
  • 加载中

Catalog

    通讯作者:陈斌, bchen63@163.com
    • 1.

      沈阳化工大学材料科学与工程学院 沈阳 110142

    1. 本站搜索
    2. 百度学术搜索
    3. 万方数据库搜索
    4. CNKI搜索
    Get Citation
    PDF
    XML

    Article Metrics

    Article views (526) PDF downloads(824) Cited by()
    Proportional views
    Related

    Address:5 Zhongguancun South Street, Haidian District, Beijing

    Tel:86-10-68914374

    Email:blgywb@bit.edu.cn

    Copy Right © Journal of Beijing Institute of Technology

    Supported by:Beijing Renhe Information Technology Co. Ltd

    /

      Return
      Return
        Baidu
        map